Cooling fans on from cold.
Moderator: Moderators
Cooling fans on from cold.
HI
I have a 2002 rapier hdi 90 which when i turn the ignition on the cooling fan/s? on radiator fire up full blast, this continues after engine starts and only goes off when ignition turned off.Any ideas? i have cleaned the relay connectors under rectangle box on rads but no better.another strange thing ive noticed is that when engine stops i can hear a noise abit like an electric motor coming from the rear of engine (turbo area) which fades out after about a minute? i dunno if this could be related or normal. my other 110 hdi doesnt make this noise.
thx in advance
I have a 2002 rapier hdi 90 which when i turn the ignition on the cooling fan/s? on radiator fire up full blast, this continues after engine starts and only goes off when ignition turned off.Any ideas? i have cleaned the relay connectors under rectangle box on rads but no better.another strange thing ive noticed is that when engine stops i can hear a noise abit like an electric motor coming from the rear of engine (turbo area) which fades out after about a minute? i dunno if this could be related or normal. my other 110 hdi doesnt make this noise.
thx in advance
"A HDI Is For Life and NOT Just For Xmas!!!"
- Welly
- The moderator formally known as Welton
- Posts: 15033
- Joined: Tue Jan 10, 2006 12:52 pm
- Location: East Midlandfordshire
Re: Cooling fans on from cold.
You could have a look at this thread, maybe the fan controls have crapped out? ...viewtopic.php?t=1452&start=0#p13555
Or it could be a coolant sensor?
MAybe this is what killed the last BSi/ECU?
Or it could be a coolant sensor?
MAybe this is what killed the last BSi/ECU?

Cars in my care:
2021 Kia Spottage 1.6 Pez Turbo Dual Clutch Gearbox Trickery
2013 Renner Twingo - donkey work
2021 Kia Spottage 1.6 Pez Turbo Dual Clutch Gearbox Trickery
2013 Renner Twingo - donkey work
Re: Cooling fans on from cold.
I'll go with coolant temperature sensor too.
<steve_earwig> I think this forum is more about keeping our cars going with minimal outlay than giving our cars more reason to go bang
Re: Cooling fans on from cold.
Thx guys ill try another coolant temp sensor.
I forgot to mention that a friend plugged his diag thingy in and one fault code found it was p0483 " Cooling Fan Rationality Check Malfunction "
just thinking on about temp sensor,,the gauge on dash read correctly does this mean sensor is behaving?
pfff...i never had these electrical problem with my austin allegro yrs ago
I forgot to mention that a friend plugged his diag thingy in and one fault code found it was p0483 " Cooling Fan Rationality Check Malfunction "
just thinking on about temp sensor,,the gauge on dash read correctly does this mean sensor is behaving?
pfff...i never had these electrical problem with my austin allegro yrs ago

"A HDI Is For Life and NOT Just For Xmas!!!"
Re: Cooling fans on from cold.
Means the ECU's getting silly readings from the sensorwasp wrote:I forgot to mention that a friend plugged his diag thingy in and one fault code found it was p0483 " Cooling Fan Rationality Check Malfunction "
Nope, the dashboard's fed from its own temp sensor (presumably so if the ECU doesn't pick up on a fault, the driver might)just thinking on about temp sensor,,the gauge on dash read correctly does this mean sensor is behaving?
You want to make sure you replace the correct sensor, unfortunately I haven't got a clue which is which (or where either are located) on your car sorry
<steve_earwig> I think this forum is more about keeping our cars going with minimal outlay than giving our cars more reason to go bang
- steve_earwig
- Moderator
- Posts: 19813
- Joined: Thu Oct 04, 2007 6:09 pm
- Location: Jastrebarsko, Croatia http://www.jastrebarsko.hr/lokacija/
Re: Cooling fans on from cold.
This would be the Bitron sensor? Haynes says on the thermostat housing on D9s (was on the oil filter housing on D8 diesels)
Unskilled meddling sin©e 2007
The submitted form was invalid. Try submitting again.
The submitted form was invalid. Try submitting again.
Re: Cooling fans on from cold.
The easy way to tell them apart is to unplug the connector on one and see if the dash stops showing the temperature 

<steve_earwig> I think this forum is more about keeping our cars going with minimal outlay than giving our cars more reason to go bang
Re: Cooling fans on from cold.
ok thank you all ,
i cant find a 2nd sensor , removed and replace the sensor on thermostat housing with a new one still no joy.resistors x2 behind rad cowling are ok, ive just swapped them with my other 406.two green relays when removed do nothing...fan still runs,but removing the smaller blue relay stops the fan.
are the 3 green relays tucked just inside the inner wing in a black box (nearside) related to fan?
removing wire to temp sensor gets message "engine to hot" and stop light on..doh cant remember if fan ran then or not..think it did.
any further help would be appreciated.
me & electrics....
maybe i should buy a fire extingisher...
Dave
i cant find a 2nd sensor , removed and replace the sensor on thermostat housing with a new one still no joy.resistors x2 behind rad cowling are ok, ive just swapped them with my other 406.two green relays when removed do nothing...fan still runs,but removing the smaller blue relay stops the fan.
are the 3 green relays tucked just inside the inner wing in a black box (nearside) related to fan?
removing wire to temp sensor gets message "engine to hot" and stop light on..doh cant remember if fan ran then or not..think it did.
any further help would be appreciated.
me & electrics....

Dave
"A HDI Is For Life and NOT Just For Xmas!!!"
Re: Cooling fans on from cold.
just a thought, are there any wiring diagrams on here for cooling fans d9?
"A HDI Is For Life and NOT Just For Xmas!!!"
Re: Cooling fans on from cold.

i think i have found the fan problem.checked out the rpo no.s on on the doner car and my car, the donor car is slightly newer and has the self combusting later fan without relays in the front! prob explaining the fault code p0483 "cooling fan Rationality Check Malfunction"
im now trying to find out if the engine ecu controls the fan and not the bsi, if so i will have to go back to peugeot ,refit the original engine ecu (which was without fault) and have it sync'd to the new bsi?
unless anyone knows of a workaround!
"A HDI Is For Life and NOT Just For Xmas!!!"
Re: Cooling fans on from cold.
The BSI controls non-essential stuff that's controlled from inside. The fans are controlled by the main ECU or bitron ECUwasp wrote:im now trying to find out if the engine ecu controls the fan and not the bsi,
<steve_earwig> I think this forum is more about keeping our cars going with minimal outlay than giving our cars more reason to go bang
Re: Cooling fans on from cold.
Thank you again mjb & everyone for all your help&timemjb wrote:The BSI controls non-essential stuff that's controlled from inside. The fans are controlled by the main ECU or bitron ECUwasp wrote:im now trying to find out if the engine ecu controls the fan and not the bsi,

"A HDI Is For Life and NOT Just For Xmas!!!"